Objective To evaluate the biocompatibility and safety of a novel orthopedics materials-graded zirconia(ZrO2)hydroxyapatite(HA) composite biomaterials. Methods First, ultrafine powers of ZrO2 and HA powder were prepared by chemical precipitation method, then graded ZrO2-HA composite was synthesized by dry-laying and sintering method. After the physiological saline and culture medium extracts of the composite were prepared, four experiments were conducted as follows:① The mouse acute toxic test consists of 2 groups(n=10). The extracts were intravenously injected to mice in the first group, and physiological saline to mice in the second group. The dose was 50 g/kg. Their toxicity manifestation, morality and the change of weight were recorded.② The standard curve of proliferation and metabolism of L929 cells was established. ③ The cytotoxinic test consists of 3 groups: materials group (extracts of the materials), positive control group (culture fluid with 0.64% phenol), and negative control group (RPMI-1640 culture fluid). Each of three was cultured with cell suspension, and then the morphology of the cells was observed, the relative proliferation rate (RGR) was calculated, and the toxicity was classified. ④ In vitrohemolytic test was divided into 3 groups: extracts, sterile distilled water (positive control) and 0.9% physiological saline. In each of three, 0.2 ml anticoagulant diluted fresh rabbit blood was added. The percentage of hemolysis was tested. ⑤ The muscle and implantation test were divided into 4 groups(n=3). The composite biomaterials were implanted into pygal muscleson either side and lateral condyles of femurs. After surgery, the rats of four groups were sacrificed at 12 and 24 weeks respectively.Tissue slice and scanning electronic microscopy were performed. Results General acute toxic test: no mouse died within 3 weeks; no toxicity symptom or adverse effects were shown within 3 days. The weight of materials group increased by 3.57±0.49 g, and the control group by 3.62±0.61 g, showing no statistically significant difference（Ρgt;0.05）.The standard curve of L929 cell perliferation and metabolism showed that their existed a positive correlation between the number of L929 cells and the perliferation. ③ Cytotoxinic test: cytosomes in the positive control group diminished and appeared round, there were pyknotic nucleus, the attached cells agglomerated; the toxicity was level Ⅳ. The morphology of cells in materials groupand negative control group was normal, and the number of them increased; the toxicity was level Ⅰand level 0, respectively. The MTT color experiments showed that positive control group was significantly lower than materials group and negative control group, showing statistically significant difference (Plt;0.01); there was no statistically significant difference between materials group and negative group.④ Hemolytic test: in vitrohemolytic rate of negative control group was0, of positive control group was 100%, and of materials group was 1.66%, which accords with the standard that hemolytic rate should be lower than 5% specified in ISO. ⑤ Implant test:No apparent rejection reaction took place after the composite was implanted; the composite bonded with the bones of the receptors firmly, which had good bonedinduced effect. Conclusion Graded ZrO2-HA composite bioceramic has good biocompatibility and is suitable for orthopedic biomaterials.
The primary results of five patients in whomthe block hydroxyapatite artificial bone (BHAB)used in maxillofacial plastic repair were reported. All incisions healed up with no evidence ofinfection. None of the implants was rejected norhad resorption changes. Satisfactory estheticaleffects were maintained. The results demonst-rated BHAB had a good biocampatibility andcould be used as a bone graft substitute inmaxillofacial plastic repair. This kind of material could be carved and contoured ...
Objective To investigate and compare the osteogenic potential of three kinds of calcium phosphate ceramic as carriers for recombinant human bone morphogenetic protein-2(rhBMP-2) in vivo.Methods BCPceramics (HA,TCP,HA/TCP) impregnated with rhBMP-2 (experimental groups) and without rhBMP-2(control groups) were implanted into 6 muscles pockets on the dorsum of 3month-old Wistar rabbits. The rabbits were sacrificed 2, 4 and 8 weeks after implantation and bone induction was estimated by alkaline phosphatase(ALP) activity measurement. The implants were also examined histologically and histomorphometrically by HE staining and computerized graphical analysis. Results The ALPactivity of implants withrhBMP-2 was higher than that of control groups(P＜0.05), but there was no difference between 2 and 4 weeks in experimental groups. In all experimental groups,theimplants exhibited that new bone formation increased with the lapse of time. The amount of new bone formation is more in -HA/rhBMP-2 group than in the other two group in the 2nd and 4th weeks, but there was no difference between them (P＞0.05).In the 8th week, the amount of bone formation was most in HA/TCP with -rhBMP-2, and was more than that in the 2nd and 4th weeks. Whereas in control groups, there was only fibrous connective tissue. Conclusion HA/TCP- is a good carriers of rhBMP-2 and can be used as bone substitutes clinically.
OBJECTIVE: To evaluate the clinical effect of drilling procedure following the hydroxyapatite orbital implantation. METHODS: From February 1996 to April 2000, 146 consecutive patients who received hydroxyapatite orbital implant were drilled and inserted a motility peg 6 to 16 months after hydroxyapatite implantation. Among them, there were 97 males and 49 females, aged from 18 to 60 years old, of the 146 motility pegs, 36 were sleeved pegs and 110 were nonsleeved. Goldman visual field analyzer was applied to measure the degree of artificial eye’s movement before and after drilling. RESULTS: Followed up for 1 to 40 months, no secondary infection occurred. The mobility of the prosthesis increased from (18.7 +/- 3.8) degrees preoperatively to (42.3 +/- 3.7) degrees postoperatively. CONCLUSION: The delayed drilling procedure and motility peg insertion improve the range of movement and the sensitivity of the artificial eye with a low rate of complications.
OBJECTIVE: To investigate the ability of repairing bone defect with the compound of coralline hydroxyapatite porous (CHAP), fibrin sealant(FS) and staphylococcus aureus injection (SAI), and the feasibility to use the compounds as bone substitute material. METHODS: The animal model of bone defect was made on the bilateral radius of 54 New Zealand white rabbits, which were randomly divided into the experimental group(the defect was repaired with CHAP-FS-SAI), control group(with autograft) and blank control group(the defect was left unrepaired) with 18 rabbits in each group. The ability of bone defect repair was evaluated by gross observation, histopathological study, X-ray and biomechanical analysis 2, 4, 8 and 12 weeks after repair. RESULTS: (1) In the 2nd week, tight fibro-connection could be found between the implant and fracture site and there were many fibroblasts and capillary proliferation with many chondrocytes around CHAP in the experimental group, while only a few callus formed, and chondrocytes, osteoblast and osteoclast existed in the control group. (2) In experimental group and control group, a large quantity of callus was found 4 and 8 weeks; ossification of chondrocytes with weave bone formation were found 4 weeks and many osteocytes and weave bones and laminar bones were found 8 weeks. (3) In the 12th week, the complete ossification of implant with well bone remodeling, a large number of mature osteocytes and laminar were found in experimental group and control group, and CHAP still existed in the experimental group; the defect area filled with fibro-scar tissue and only many fibroblasts could be seen in blank control group. (4) X-ray findings were the following: In experimental and control groups, callus formation could be seen 2 weeks postoperatively, more callus formed 4 weeks, the bone defect area disappeared and CHAP scattered in the callus 8 weeks; the fracture line disappeared and medullary cavity became united (in control group); and in the 12th week, the cortex became continuous, the medullary cavity became united, and remodeling completed, while bone defect was not still united in blank control group. The maximal torque and torsional stiffness in the experimental group is higher than those in the control group 2 weeks (P lt; 0.05), but there was no significant difference (P gt; 0.05) between the two groups 4, 8, 12 weeks after repair. CONCLUSION: The compound of CHAP-FS-SAI has good biological compatibility, and it can be used for one kind of bone substitute material to repair the bone defect.
To observe the collagen-hydroxylaptite composite in the repair of bone defect, ten minipigs were chosen to make a mandibular dafect measuring 2 cm in diameter and the composite was implanted, while the use of autogenous bone graft and the blank wese served as control. On the 4, 8, 12, 24 and 48 weeks after the operation, the animals were sacrificed and the samples were examined under light microscope. The result showed that: no infection or necrosis occurred. The composite coalesced with host bone and the outcome was similar to that of the autogenous bone graft. No foreign body giant cells or vacuum left from osteonecrosis was observed. It was suggested that the composite had the advantage of abundant supply, easy to handle and no harm. The biocompatibility was good and might be hopeful as a bone substitute.
In order to investigate the stability of Hydroxyapatite (HA) coated material, the plasma-sprayed coatings of HA were divided into four groups: 1. Keeping in water vapour at 125 degrees C, with a pressure of 0.15 MPa for 6 hr; 2. Heating at 650 degrees C in air for half an hr; 3. Keeping in water vapour at 490 degrees C, with a pressure of 0.01 MPa for 2 hr; and 4. The control. The XRD, FTIR analysis and the dissolution test were carried out. The results showed: 1. The degree of crystalization in XRD analysis was 3. gt; 1. gt; 2. gt; 4.; 2. The ampitude of OH- peak in FTIR analysis was 3. gt; 1. gt; 2. gt; 4. and 3. The dissolution rate in tris-HCl buffer was 3. lt; 1. lt; 2. lt; 4. The conclusions were 1. The treating with water vapour could decrease the transformation temperature which was needed to convert the amorphous phase into cystalline phase; 2. Water vapour treatment could accelerate the transformation of Z-TCP, TCPM into crystalline HA; 3. Water vapour treatment could promote the structural integrity of plasma--sprayed coated of and HA and 4. Water vapour treatment could lower the dissolution rate of HA coated in Tris-HCl buffer.
Objective To investigate the ability of repairing bone defect with the compound of recombinant human insulinlike growth factor 1 (rhIGF-1), coralline hydroxyapatite(CHA) and autogeneous red bone marrow(ARBM), and to study the feasibility of the compounds being used as bone substitute materials. Methods Bilateral radius bone defects(11 mm in length) were created in 54 Chinese rabbits,which were randomly divided into 3 groups, and two different materials were randomly transplanted into the bilateral defects:in group 1, with material A(rhIGF-1/CHA/ARBM) and material B(CHA/ARBM); in group 2, with material C(rhIGF-1/CHA) and material D(CHA); in group 3, with E(autograft) and F(no implant) as controls. At 2, 4, 8 and 12 weeks, the effects were assessed by X-ray andimage analysis, biomechanics(at 12 weeks), as well as histological observation. Results X-ray and image analysis showed that material A of group 1was significantly superior to any other materials(P＜0.01). Antibending biomechanic detection showed that material A and Ewas significantly superior to the other materials(Plt;0.01), but no significant difference was found between A and E in the 12th week(Pgt;0.05). And by histological observation, in analogical bone morphological progress, materials C and D obviously inferior to materials A, B and E, but there was no significant difference between materials C and D. F had no evidence of new bone rebridging. Conclusion The recombinant compound CHA/ARBM(rhIGF-1),which posseses the potential ability of osteogenesis,osteoconduction and osteoinduction for bone defect repairing,can serve as a new type of autogenous bone substitute material.
ObjectiveTo evaluate the in vivo biological safety of porous zinc oxide (ZnO)/hydroxyapatite (HA) composite materials.MethodsThe porous ZnO/HA composite materials and porous HA materials were prepared by the spark plasma sintering technology. First, the materials were characterized, including scanning electron microscopy to observe the material structure, in vitro degradation experiments to detect the degradation rate of the materials, and inductively coupled plasma emission spectrometer to detect the concentration of Zn2+ dissolved out of the composite material degradation. Then the two kinds of material extracts were prepared for acute systemic toxicity test. Fifteen male Kunming mice were randomly divided into groups A, B, and C (n=5) and injected intraperitoneally with normal saline, HA extracts, and ZnO/HA extracts, respectively. The body mass of the mice was recorded before injection and at 24, 48, and 72 hours after injection. The liver and kidney tissues were taken at 72 hours for HE staining to evaluate the safety of the composite material. Finally, the biological safety of the material in vivo was evaluated by implantation experiment. The eighteen male New Zealand white rabbits were randomly divided into HA group and ZnO/HA group (n=9); a bilateral radius defect model (1 cm) was established, and the right forelimbs of the two groups were implanted with porous HA materials and porous ZnO/HA composite materials, respectively; the left untreated as a blank control. The general condition of the animals were observed after operation. The rabbit blood was collected at 1 day before operation and at 1 day, 1 week, 4 weeks, and 8 weeks after operation for routine blood test (inflammation-related indicators) and blood biochemistry (liver and kidney function-related indicators). X-ray films were taken at 4, 8, and 12 weeks after operation to observe the repair of bone defects.ResultsMaterial characterization showed that porous ZnO/HA composite materials had interconnected large and small pore structures with a pore size between 50 and 500 μm, which degraded faster than porous HA materials, and continuously and slowly dissolved Zn2+. The acute systemic toxicity test showed that the mice in each group had no abnormal performance after injection, and the body mass increased (P<0.05). HE staining showed that the cells shape and structure of liver and kidney tissue were normal. Animal implantation experiments showed that all rabbits survived until the experiment was completed; routine blood tests showed inflammation in each group (neutrophils, monocytes, and lymphocytes increased) at 1 day after operation, and all returned to normal at 8 weeks (P>0.05); compared with 1 day before operation, the content of inflammatory cells in the HA group increased at 1 day, 1 week, and 4 weeks after operation (P<0.05), and the ZnO/HA group increased at 1 day after operation (P<0.05); blood biochemistry showed that the liver and kidney function indexes were in the normal range; X-ray films showed that the ZnO/HA group had better osseointegration than the HA group at 4 weeks after operation.ConclusionThe porous ZnO/HA composite material has good in vivo biological safety and good bone repair ability, which is a potential bone repair material.